$50 Reward...Identify my Rattle
#22
Bullitt Member
Join Date: November 10, 2008
Location: Las Vegas
Posts: 408
Likes: 0
Received 0 Likes
on
0 Posts
The last time I took my car in for that TSB: 08-4-3, It stopped making that sound a day before she went in. Of course the dealer couldn't reproduce the sound.
Will I catch flack with the intake and the tune?
Will I catch flack with the intake and the tune?
#23
Shelby GT500 Member
Join Date: January 30, 2004
Location: Riverside, CA
Posts: 2,916
Likes: 0
Received 0 Likes
on
0 Posts
You shouldn't as its not related to your mods.
Only on Engine driveabilty type concerns will they ask you to remove it. Usually most places don't burn you, and ask you to return to stock before they will service your vehicle under warranty.
Thanks again Andrew! I'm glad you found the rattle.
Only on Engine driveabilty type concerns will they ask you to remove it. Usually most places don't burn you, and ask you to return to stock before they will service your vehicle under warranty.
Thanks again Andrew! I'm glad you found the rattle.
#25
you know when I have my car set to factory tune and run regular cheap gas it does that , but if I install any tune 91 per/ 91 torqu / or 93 race with primium fuel , the engine is Happy.
#28
it is the seperator plate/bell housing issue. it is a very common problem. here is the TSB:
http://www.2005stang.com/gallery/alb...SB_08-2-10.pdf
I had this done and that rattle has gone away. Point your dealer to this TSB and everything should be ok. Car sounds great now.
http://www.2005stang.com/gallery/alb...SB_08-2-10.pdf
I had this done and that rattle has gone away. Point your dealer to this TSB and everything should be ok. Car sounds great now.
#29
Mach 1 Member
Join Date: September 24, 2004
Location: Victoria, BC, Canada
Posts: 901
Likes: 0
Received 1 Like
on
1 Post
it is the seperator plate/bell housing issue. it is a very common problem. here is the TSB:
http://www.2005stang.com/gallery/alb...SB_08-2-10.pdf
I had this done and that rattle has gone away. Point your dealer to this TSB and everything should be ok. Car sounds great now.
http://www.2005stang.com/gallery/alb...SB_08-2-10.pdf
I had this done and that rattle has gone away. Point your dealer to this TSB and everything should be ok. Car sounds great now.
I called today and it is covered under the drivetrain warranty, I just have to show there is a rattle. SAAAAAWEEEET!
#31
Member
Thread Starter
Join Date: August 2, 2007
Location: Ottawa
Posts: 42
Likes: 0
Received 0 Likes
on
0 Posts
Last night I undid the two bolts and slit some foam rubber tape between the plate and the bell-housing. Problem solved...for now. In the spring I'll send it to work with my neighbour, maybe when I have a drive-shaft or gears or something to install.
Thanks again guys...50 bucks well spent. Today I drove the car to work, and I actually enjoyed myself instead of being pissed off about some rattle...not to mention the Adrenalines sound really good--they're a bit deeper and louder than the GTAs at idle, and sound great when I open er up
Thanks again guys...50 bucks well spent. Today I drove the car to work, and I actually enjoyed myself instead of being pissed off about some rattle...not to mention the Adrenalines sound really good--they're a bit deeper and louder than the GTAs at idle, and sound great when I open er up
#32
Mine only had the rattle cold. It also had the missing bolts in the bottom that had been replaced. Well putting on my headers I removed the bolts and put a flat washer between plate and bellhousing. This has been the fix for mine since it has been out of warranty. When I need to replace the clutch is when I will update the separator plate.
#33
I have an 07 gt auto with same issue.......dealer removed h pipe hangers, but another metalic sound exhists. This sound occours at 45mph and up and is not rpm related as was the hanger problem. It sounds as though a smaller pipe is in a larger pipe with out a clamp to stop rattle. The dealer can not hear the noise even when I test drive with him. The noise seems to be comming from just in front of driver's feet.
#37
Super Boss Lawman Member
Remove the cats and run straight pipes, you will no longer hear the rattle. My paypal is alay3434, i'll expect paymeny by the end of the week...
lol
lol
Last edited by SONICBOOST; 6/2/11 at 03:48 PM.
Thread
Thread Starter
Forum
Replies
Last Post
robjh22
Suspension, Brakes, and Tire Tech
4
9/8/15 12:31 PM